久久成人在线观看_91视频首页_国产成人免费视频_国产成人一区_久久久久国产一区二区_国产一区二区三区在线免费

沼氣發電機組發電在氣體流量計的使用!

發布時間:2023-03-23 發布人:中拓 發布來源:http://www.ptvydps.cn/
在沼氣發電過程中,沼氣發電機組對沼氣的成分、溫度、壓力、用量特別敏感,發電機組要求進氣系統必須保持空燃比的恒定和適度,避免空燃比過大,引起熄火;也要避免空燃比過小,引起溫度高及爆震。空燃比是影響沼氣發電機燃燒性能的重要因素之一,而沼氣溫度、壓力、成分的變化都會影響空燃比,因此,在選擇進行沼氣發電前,不對沼氣氣質進行合理的把控,將導致發電機組無法正常運行,造成較大的經濟損失。
In the process of biogas power generation, biogas generator units are particularly sensitive to the composition, temperature, pressure, and amount of biogas. The generator unit requires that the intake system must maintain a constant and moderate air-fuel ratio to avoid excessive air-fuel ratio that may cause flameout; It is also necessary to avoid excessively low air-fuel ratio, which can cause high temperature and detonation. The air-fuel ratio is one of the important factors that affect the combustion performance of biogas generators, and changes in the temperature, pressure, and composition of biogas can affect the air-fuel ratio. Therefore, before choosing to use biogas for power generation, not properly controlling the biogas quality will lead to the inability of the generator unit to operate normally, resulting in significant economic losses.
1、沼氣質量
1. Biogas quality
利用沼氣發電,要滿足沼氣發電機組對沼氣質量的要求,《中大功率沼氣發電機組》(GBT29488-2003)、《沼氣電站技術規范》(NY/T1704-2009)對沼氣質量的要求如下。
To generate electricity using biogas, it is first necessary to meet the requirements for biogas quality of biogas generating units. The requirements for biogas quality in the Medium and Large Power biogas generating units (GBT29488-2003) and the Technical Specifications for Biogas Power Plants (NY/T1704-2009) are as follows.
(1) 沼氣低位發熱值≥14MJ/Nm,相當于沼氣中甲烷體積分數不小于30%。沼氣中甲烷在30s內的體積分數變化率不應超過2%,機組連續運行期間沼氣中甲烷體積分數變化率不超過5%。
(1) The low calorific value of biogas is ≥ 14MJ/Nm, which is equivalent to the methane volume fraction in biogas not less than 30%. The change rate of methane volume fraction in biogas within 30s shall not exceed 2%, and the change rate of methane volume fraction in biogas during continuous operation of the unit shall not exceed 5%.
(2) 沼氣溫度不高于50℃。
(2) The temperature of biogas shall not be higher than 50 ℃.
(3) 沼氣發電機組對沼氣成分的具體要求如下表。
(3) The specific requirements for biogas components of biogas generator units are shown in the table below.
注:沼氣體積的標準參比條件是101.3kPa,20℃;按照沼氣中所含硫成分全部轉化為硫化氫計算。
Note: The standard reference condition for biogas volume is 101.3kPa, 20 ℃; Calculated based on the conversion of all sulfur containing components in biogas into hydrogen sulfide.
①H2S對發電機組的影響
① Impact of H2S on generator sets
沼氣發電時沼氣中的H2S會對沼氣發電機組的進氣管道、增壓器、中冷器、火花塞、氣缸套、排氣管和消音器等造成嚴重腐蝕,從而影響機組壽命,所以沼氣在進入發電機組之前必須進行沼氣預處理,將H2S降到機組允許的范圍內才能保證機組的可靠運行。
During biogas power generation, H2S in biogas can cause serious corrosion to the intake pipes, superchargers, intercoolers, spark plugs, cylinder liners, exhaust pipes, and silencers of the biogas generator unit, thereby affecting the unit's life. Therefore, biogas pretreatment must be conducted before biogas enters the generator unit to reduce H2S to the allowable range of the unit to ensure reliable operation of the unit.
②水分對發電機組的影響
② Effect of moisture on generator sets
沼氣發電過程中,沼氣水分含量過大,會導致發電機組的進氣壓力損耗過大,嚴重情況下,會引起發動機功率波動、敲缸、停機等問題,嚴重地影響其使用壽命。其具體表現為:
During biogas power generation, excessive moisture content in biogas can lead to excessive intake pressure loss of the generator set. In severe cases, it can cause engine power fluctuations, cylinder knocking, shutdown, and other issues, seriously affecting its service life. The specific performance is as follows:
燃氣發電機組
(a)發動機點火困難;
(a) Difficulty in ignition of the engine;
(b)降低燃燒室溫度,降低內燃機效率;
(b) Reduce combustion chamber temperature and reduce internal combustion engine efficiency;
(c)水蒸氣等無功氣體的存在,會增壓和增大功耗;
(c) The presence of reactive gases such as water vapor can pressurize and increase power consumption;
(d)水蒸氣與其他酸性物質化合產生的中間產物,會對發電機組產生腐蝕,縮短使用壽命,降低可靠性。
(d) The intermediate products produced by the combination of water vapor and other acidic substances can cause corrosion to the generator set, shorten its service life, and reduce its reliability.
③粉塵對發電機組的影響
③ Impact of dust on generator sets
粉塵是發動機明確限制的雜質,它主要影響在于:
Dust is a clearly restricted impurity in the engine, and its main impact is:
(a)堵塞管路,流通不暢,加大壓損,增加運行費用;
(a) Blocking the pipeline, impeded circulation, increased pressure loss, and increased operating costs;
(b)增大機械磨損,降低設備使用壽命。
(b) Increase mechanical wear and reduce equipment service life.
2、沼氣壓力
2. Biogas pressure
沼氣發電機組在距離機組燃氣支管錢1m處的沼氣壓力不低于3kPa,當供氣壓力低于3kPa時,應配置氣體增壓設備;當供氣壓力超過5kPa時,則需要增加合適的減壓閥。在沼氣發電機組運行時,發動機允許的沼氣壓力波動一般要小于0.4kPa/s。
The biogas pressure of the biogas generator unit at a distance of 1m from the unit gas branch pipe shall not be lower than 3kPa. When the gas supply pressure is lower than 3kPa, gas boosting equipment shall be equipped; When the air supply pressure exceeds 5kPa, it is necessary to add a suitable pressure reducing valve. When the biogas generator unit is running, the allowable biogas pressure fluctuation of the engine is generally less than 0.4 kPa/s.
3、沼氣用量
3. Biogas consumption
沼氣發電機組的沼氣用量應根據發電機組的效率和負荷確定,發電時沼氣的供氣量應相對穩定。在計算沼氣使用量時,應小于沼氣發電機額定功率耗氣量的1.2倍。供氣系統應設有調節用氣的設施和氣體計量儀表。沼氣發電機組連續運行時,儲氣裝置容量應按照運行機組總額定功率大于3h的用氣量設計。沼氣發電機組間歇運行時,儲氣裝置容量應按照大于間斷發電時間的沼氣總量設計。
The amount of biogas used in a biogas generator unit should be determined based on the efficiency and load of the generator unit, and the amount of biogas supplied during power generation should be relatively stable. When calculating the amount of biogas used, it should be less than 1.2 times the rated power consumption of the biogas generator. The gas supply system shall be equipped with facilities for regulating gas consumption and gas metering instruments. During continuous operation of biogas generating units, the capacity of the gas storage device should be designed based on the gas consumption with the total rated power of the operating unit greater than 3h. When the biogas generator unit operates intermittently, the capacity of the gas storage device should be designed based on the total amount of biogas that is greater than the intermittent power generation time.
其中,沼氣發電機組的用氣調節系統,一般采用電子調速系統控制碟門開度來實現的,調速系統由轉速傳感器、速度控制器、執行器和驅動器組成,構成閉環的速度調節與控制系統,實現對混合氣體進氣量的控制。氣體計量儀表一般是采用沼氣流量計,如銳意自控超聲波氣體流量計BF-3000/BF-3000B,用以實時計量沼氣的瞬時流量和累計流量,為計算沼氣使用量提供科學的數據支撐。
Among them, the gas consumption regulation system for biogas generating units is generally achieved by using an electronic speed regulation system to control the opening of the disc door. The speed regulation system consists of a rotational speed sensor, a speed controller, an actuator, and a driver, forming a closed-loop speed regulation and control system to achieve control of the intake amount of mixed gas. Gas metering instruments generally use biogas flow meters, such as the Ruiyi Automatic Ultrasonic Gas Flowmeter BF-3000/BF-3000B, to measure the instantaneous and cumulative flow of biogas in real time, providing scientific data support for calculating the amount of biogas used.
更多的關于燃氣發電機組的問題或者詳細的內容,請進入我們公司的網站:http://www.ptvydps.cn網站中會有很多的內容僅供參考。
For more questions or detailed information about gas turbine generators, please visit our company's website: http://www.ptvydps.cn There will be a lot of content on the website for reference only.

截屏,微信識別二維碼

  • 主站蜘蛛池模板: 精品一区二区在线观看 | 国产无套粉嫩白浆在线观看 | 日韩成人在线网站 | 免费精品国偷自产在线2020 | 一本加勒比hezyo无码资源网 | 国产热热 | 国产欧美日韩高清专区ho | 一级片在线免费看 | 久久综合中文字幕一区二区三区 | 免费网站国产 | 99视频都是精品热在线播放 | 国产99精品在线观看 | 伊人狠狠色丁香综合尤物 | 我要看一级毛片 | 免费看www网站入口 免费看成年视频网页 | 日韩高清一区二区三区五区七区 | 激情做人爱免费视频 | 18末成年禁止进入免费观看 | 国产一区高清 | 久久精品国产99久久香蕉 | 最近中文字幕最新在线视频 | 国产精品成人久久久 | 亚洲日韩中文字幕无码一区 | 麻豆精品久久久 | 狠狠色噜噜狠狠狠狠97老肥女 | 巨大乳女人做爰视频在线看 | 免费观看小视频 | 高清视频在线观看一区二区三区 | 四虎国产一区 | 日韩在线视频线视频免费网站 | 欧美视频在线观看爱爱 | 国产精品自拍在线 | 久久精品久久久久久久久人 | 在线观看国产精品入口 | 久久婷婷五月综合国产尤物app | 亚洲色大成网站www永久麻豆 | 成人a级毛片免费观看 | 中文字幕av无码免费一区 | 精品露脸国产偷人在视频 | 亚洲精品无码少妇30p | 香蕉久久久久久久av网站 |