沼氣發電機組是現代新型的一種環保發電設備，因為這種設備的環保特性在現代被大量的使用，那么大家知不知道其實在運行沼氣發電機組的時候有一些事情是需要被注意到的，如果不知道的話，接下來就由小編帶大家了解清楚。

Biogas generator set is a new type of environmentally friendly power generation equipment in modern times. Due to the environmental characteristics of this equipment, it is widely used in modern times. Do you know that there are some things that need to be paid attention to when operating biogas generator sets? If not, let me take you to understand.

在進行沼氣發電時，必須控制好沼氣發酵環境，保證發電的效率和質量，因此在使用沼氣發電機組時要注意以下四個方面：

When conducting biogas power generation, it is necessary to control the biogas fermentation environment to ensure the efficiency and quality of power generation. Therefore, when using biogas power generation units, attention should be paid to the following four aspects:

1、剛采購過來的沼氣發電機組，在運行了50個小時建議進行一次常規保養，因為機組的磨合期的保養至關重要，操作人員必須經常檢查沼氣發電機組進氣管路，防止沼氣泄漏和冷凝水過多而影響供氣。

1. The newly purchased biogas generator unit is recommended to undergo routine maintenance after running for 50 hours, as the maintenance during the unit's running in period is crucial. Operators must regularly check the intake pipeline of the biogas generator unit to prevent biogas leakage and excessive condensate from affecting the gas supply.

2、沼氣發電機工作時應經常巡視、檢查沼氣發電機組的運行情況，沼氣脫硫及穩壓、防爆裝置，另外，為了防止進氣管回火引起沼氣管路發生爆炸，應在沼氣供應管路上安置防回火與防爆裝置，發現問題應及時調整或上報有關領導。

2. During the operation of the biogas generator, it is necessary to regularly inspect and inspect the operation of the biogas generator set, as well as the biogas desulfurization, stabilization, and explosion-proof devices. In addition, to prevent the explosion of the biogas pipeline caused by the backfire of the intake pipe, anti backfire and explosion-proof devices should be installed on the biogas supply pipeline. If any problems occur, they should be adjusted or reported to relevant leaders in a timely manner.

3、進氣系統：沼氣發電機在運行中，操作人員應隨時掌握負載變化情況并應對沼氣發電機的大負荷進行限制，在進氣總管上，需加裝一套沼氣一空氣混合器，以調節空燃比和混合氣進氣量。

3. Air intake system: During the operation of the biogas generator, the operator should always be aware of the changes in load and limit the large load of the biogas generator. A set of biogas air mixer should be installed on the main intake pipe to adjust the air-fuel ratio and mixed gas intake.

4、發動機：沼氣的燃燒速度很慢，所以對沼氣發動機有較高的要求。沼氣發電機的過濾裝置應定期清洗。

4. Engine: The combustion speed of biogas is very slow, so there are high requirements for biogas engines. The filtration device of the biogas generator should be cleaned regularly.

5、調速系統：沼氣發電機組沼氣進氣壓力不得低于1.8kPa，沼氣發動機的運行場合是和發電機一起以用電設備為負荷進行運轉，為了確保發電機正常發電，沼氣發動機上的調速系統必不可少。

5. Speed regulation system: The biogas intake pressure of the biogas generator set shall not be lower than 1.8kPa. The operation of the biogas engine is carried out together with the generator under the load of electrical equipment. In order to ensure the normal power generation of the generator, the speed regulation system on the biogas engine is essential.

本文由燃氣發電機組友情奉獻.更多有關的知識請點擊:http://www.ptvydps.cn 真誠的態度.為您提供為全面的服務.更多有關的知識我們將會陸續向大家奉獻.敬請期待.

This article is dedicated to the friendship of gas generators. For more information, please click: http://www.ptvydps.cn Sincere attitude. We will provide you with comprehensive service. We will gradually contribute more relevant knowledge to everyone. Stay tuned